Antenna Radar Tank Level Sensor

Antenna Radar Tank Level Sensor

This series of Radar Level Meter adopted high frequency radar sensor. Antenna is optimized further processing, the new fast microprocessors have higher speed and efficiency can be done signal analysis, the instrumentation can be used for reactor, solid silo and very complex measurement environment.

Small antenna size, easy to install; Non-contact radar, no wear, no pollution.
Almost no corrosion, bubble effect; almost not affected by water vapor in the atmosphere, the temperature and pressure changes.
Serious dust environment on the high level meter work has little effect.
A shorter wavelength, the reflection of solid surface inclination is better.
Beam angle is small, the energy is concentrated, can enhance the ability of echo and to avoid interference.
Flotation Froth Image Analyzer is large. A good measuring result will be got in the measuring process.
High signal-to-noise ratio, the level fluctuation state can obtain better performance.
High frequency, measurement of solid and low dielectric constant of the best choice.

Product Features

Strong environmental adaptability: can adapt to the harsh industrial site environment.

Highly corrosive environment: Radar Level Control is made of corrosion-resistant materials and can adapt to most corrosive environments such as strong alkalis.

There are no special requirements for the composition of the materials to be measured: Radar Level Gauge is not affected by bubbles; Radar Type Level Transmitter is low affected by large particles; Radar Level Meter is not affected by magnetic interference.

The detection range of particle size is wide: the maximum size range of 60 percentage points can be detected, and the minimum size range of 20 percentage points can be detected.

The size fraction span is large: The particle size measurement can be achieved in the diameter of the grain between 20μm to 1000μm.

Product Parameter

The maximum detectable flow channel number 1
The number of size fraction that can be detected at the same time in each channel ≤2
The grain diameter range that can be detected (μm) 20 ～ 1000
The nominal detectable particle size interval per size fraction (%)
Size fraction	Interval
μm：-75 ～ -850 mesh：200 ～ 20	20 ～ 80
μm：-45 ～ -75 mesh：325 ～ 200	30 ～ 70
μm：-25 ～ -45 mesh：500 ～ 325	70 ～ 95
Maximum nominal particle size span (percentage point) 30
the absolute error in the 1σ (%) 1 ~ 2
Analog output：4 ~ 20mA
Level of protection：detector：IP65；main control box：IP54
Ambient temperature：0 ~ +50℃
Medium environment：1 ~ 90℃
Medium pressure：86 ~ 106KPa
Power supply：220V AC，50Hz，50W

Product Application

It is mainly used to detect and analyze the particle size of the hard grain in the liquid and solid mixture slurry. PSI can be used in the grinding and dressing fields of black metal industry, basic metal industry, industrial mineral industry, and gold industry.

Contact us if you need more details on Sensor Level Transmitter. We are ready to answer your questions on packaging, logistics, certification or any other aspects about Radar Level Sensor、Radar Level Transmitter Interfaces. If these products fail to match your need, please contact us and we would like to provide relevant information.

Product Categories : Radar Level Transmitter